Focus RS

Focus RS Explore Our Stock

Focus RS Limited

Focus RS Limited Explore Our Stock

Mustang

Mustang Explore Our Stock

Ranger Raptor

Ranger Explore Our Stock

Transit Van

Transit Custom Explore Our Stock

Transit Custom

Transit Custom Explore Our Stock

Transit Cab Chassis

Transit Custom Explore Our Stock

Mechanical Protection Plan

Enquire Now
 Standard Cover

Engine

All internally lubricated parts, including: Camshaft, connecting rods and rod bearings, crankshaft and main bearings, gudgeon pins, oil pump, pistons, piston rings, push rods and lifters, rocker arms, timing chain, timing gears, valves, valve guides and seats, valve springs.

Excluded from this cover are:
Cylinder head(s), engine block or barrels or blown head gaskets.

Differential & Drive Line

Bearings, centre bearings, crown wheel and pinion, drive axle housing if damage is due to failure of internally lubricated components, drive shafts, gears, half shafts, limited slip clutch pack, U and CV joints.

Braking System

Brake booster, calipers, hydraulic brake lines, master cylinder, wheel cylinders.

Suspension

Control arms, top and bottom ball joints, radius rod bushes, stub axles, wheel bearings. (Applies to front suspension only)

Fuel Management System

Fuel pumps, injectors, injector pump.

Transmission

Internally lubricated parts only.
Transmission case if damage is due to failure of internally lubricated components.

Clutch Assembly

2WD vehicles only.
Clutch fork, clutch master, pressure plate, slave cylinder, throw out bearing.

Cooling System

Electric fan thermostat, fan hub, radiator cooling fan motor, thermostat, water pump.

Steering

Idler arms, pitman arms, power steer box, power steering pump, steering rack, tie rod ends.

Electronics & Electro-Mechanical

Alternator, engine management computer, starter motor, voltage regulator, wiper motor.

Air Conditioning

Compressor, compressor clutch.

Body & Interior

None

Premium Cover

Engine

All internally lubricated parts, including: Balance shafts, big end bearings, camshaft, camshaft pulley, camshaft tower, connecting rods, crankshaft and main bearings, distributor, EGR valve, flex plate, flywheel, gudgeon pins, harmonic balancer, idler pulleys, oil pressure relief valve, oil pump, oil sender unit, pistons, piston rings, push rods and lifters, rocker arms and shafts, starter ring gear, throttle cables, throttle linkages, timing belt pulleys, timing chain, timing gears, turbo (factory fitted), valves, valve guides and seats, valve springs, valve stem seals, waste gates.

Excluded from this cover are: Cylinder head(s), engine block or barrels or blown head gaskets.

Differential & Drive Line

Axle hub bearings, axle shafts, bearings, bushings, centre bearings, crown wheel and pinion, drive axle housing if damage is due to failure of internally lubricated components, drive shafts, front hub bearings, gears, half shafts, limited slip clutch pack, locking hub assemblies, swivel hubs, U and CV joints.

Braking System

Brake booster, brake linkages, brake pedal box, brake pressure limiter, calipers, handbrake cable, handbrake mechanism, hydraulic brake lines, master cylinder, roportioning valve, wheel cylinders.

Suspension

Bump stop cushions, control arms, radius rod bushes, steering rack mounts, stub axles, sway bar bushes, tension rod, top and bottom ball joints, wheel bearings. (Applies to front and rear suspension)

Fuel Management System

Accelerator pump, fuel pumps, fuel relay, fuel sender unit, injectors, injector pump, pressure regulator, solenoids, vacuum pump.

Transmission

All internal mechanical parts including: Accumulators, bearings, chain and sprockets, clutch and band assemblies, electric shift control unit, gears, inhibitor switch, interlock control unit, oil pump, over drive clutch, pressure switches, selector forks, selector shafts, servo units, solenoids, speedo transducer, synchromesh assembly, torque converter case and transmission case if damage is due to failure of internally lubricated components, valve body.

Clutch Assembly

2WD vehicles only.
Clutch cable, clutch fork, clutch linkage, clutch master, clutch pedal box, pressure plate, slave cylinder, spigot bearing, throw out bearing.

Cooling System

Electric fan thermostat, fan hub, heater tap, radiator cooling fan motor, thermostat, water pump.

Steering

Centre links, idler arms, pitman arms, power steer box, power steering pulley, power steering pump, steering column and bushes, steering lock, steering rack, tie rod ends, tilt lever.

Electronics & Electro-Mechanical

Aerial motor, air suspension compressor, alternator, central locking actuator, door light actuator and switch, electric boot release, engine management computer, hazard light switch, headlight motors, headlight switches, indicator switches, key remote, load proportioning valve, mechanical switches, mirror motors, mirror switch, power seat motors, rear demister switch, remote fuel release mechanism and cable, starter motor, sun roof motor, voltage regulator, window motors, window regulators, windscreen washer motors, windscreen wiper arms and linkages, wiper motor, wiper switches.

Air Conditioning

A/C switch, blend door motor, compressor, compressor bearings, compressor clutch, idler pulley, idler pulley bearing, recycle vent flap, TX valve, vacuum control switch.

Body & Interior

Accelerator pedal and cable, bonnet hinges, bonnet lock and cable, bonnet striker, bonnet struts, boot hinges, boot lock and cable, boot lock striker, boot struts, door handles and rods, door hinges, door locks and cable, door strikers, glove box lock, locks, seat belt tensioners and locking mechanism, seat recliner mechanism, seat runners, speedo cable, T/bar and bushes, vent cables.

What is Not Covered

The benefits of our Mechanical Protection Plan apply only to the parts listed under “PARTS COVERED” within this booklet. Any parts not listed therein are specifically excluded. This Contract does not cover the following:

  1. Any failure caused by negligence, misuse or failure to perform required servicing, or any failure caused by the lack of proper and necessary maintenance. Any failure due to the lack of oil or coolant, excessive use of oil, overheating, fuel contamination or use of incorrect grade of fuel is not covered under this Contract.
  2. Any parts not listed under “PARTS COVERED” in this booklet. Maintenance items such as, but not limited to, the following are not covered by this Contract: brake pads, brake rotors, spark plugs, light bulbs, batteries, oils, filters, tyres, hoses, fan and timing belts, shock absorbers, struts, or any other component recommended by the Manufacturer for periodic replacement.
  3. Seals and gaskets.
  4. Any modifications made or any affected components on the Vehicle after the Date of Delivery from our Dealership, unless fitted by our Dealership, or with written approval for inclusion by our Dealership.
  5. Paint, trim, or failure caused by rust or corrosion of any kind.
  6. Any inherent faults or defective parts subject to recall by the Manufacturer, or any such parts recommended for replacement by the Manufacturer through inability to meet normal performance requirements.
  7. Any loss or damage caused by towing, collision, force impact, breakage of glass, missiles, falling objects, fire, theft or larceny, explosion, earthquake, windstorm, hail, water, flood, malicious mischief or vandalism, riot or civil commotion, lightning, nuclear contamination, freezing, smoke, or from any other cause whatsoever except as provided in this Contract.
  8. Consequential damage.
  9. Any electronic or computer software upgrade or hardware upgrade.
  10. Any clutch components where the Vehicle is four wheel drive or all wheel drive.
  11. All consumables, including but not limited to, oils, coolants, lubricants, additives, air conditioning gas, environmental and waste disposal charges.

Enquire Below

Powered by ChronoForms - ChronoEngine.com

Terms and Conditions

To keep the Mechanical Protection Plan and Roadside Assist Coverage valid you must have your car serviced only at our service centre. If your vehicle is still under manufacturer's cover, you will enjoy the benefits of the extended plan if the car is serviced by us, in accordance with the specifications set out in the owner's manual at prevailing rates, until that warranty expires.

If you choose to have these services done elsewhere you may not necessarily void your Manufacturer's Warranty, however we will not be able to offer you our extended coverage. Any claims/repairs must be taken back to our dealership unless you are outside a 5okm radius from the dealership, then you should contact 1300 728 687 to get an authorisation. A claim will not be paid without an authorisation number. The plan covers wear and tear of all covered components.

Services done elsewhere will not be approved or recognised. The cover provided by the plan begins on the expiry of your Manufacturer's Full Warranty or Statutory Warranty but the Terms & Conditions start from day one.

This contract is not transferable. Refer to the Mechanical Protection Plan brooklet for full terms and conditions including full benefits and your rights under the Australian Consumer Law.